Project Name: IMEB3 Regenerative Braking Motor Assembly and Inspection
End User: SNT MOTIV
Main Components: PLLAB Motor Controller, HIOKI ST5520, KEYSIGHT LCR Meter, NI 8512 (CAN)
Description:
This project involves assembling regenerative braking motors for electric vehicles and inspecting various parameters such as cogging, friction, insulation, inductance, back EMF, torque, torque ripple, and noise/vibration. Based on these measurements, it determines whether the motor is a good product or defective.
During the assembly and inspection process, all measurement data is saved in Excel format on each PC and then transmitted to the main servers MES database. The saved data can be reviewed to ensure defective products are not shipped. Furthermore, it enables tracing of where and why defects occur by analyzing the inspection results.
NI Data Logging Program - Electricity & Electronic
To replace the portable recorder used by Hyundai Electric, a new data collection and analysis program based on LabVIEW was developed.
To solve problems with existing portable equipment that is difficult for workers to use due to aging or performance issues, a more intuitive UI and better data processing functions can be provided.
You can measure the voltage of generators, circuit breakers, etc. to collect voltage data in the field, and you can check the filtered data, RMS, and peak by channel. There is also a data storage function and a function to check the stored data as a graph.
Large Outdoor Noise Inspection Syste
Project Name: Large Outdoor Noise Inspection System
End User: LG Electronics
Equipment used: LabVIEW, NI-9425, SeeSV-S206W, GMES
Contents: This project uses SMIs SeeSV-S206W sound camera to inspect the abnormal noise of large outdoor unit production products and link the result of judgment to the MES. Up to three areas of interest desired by the user
4-axis control sound collection system - Electric
Project Name: 4-axis control sound collection system
End User: Pusan National University
Equipment used: LabVIEW, MD200T 2CH Motor Driver, 30W BLDC Motor
Contents: The project is to control the 4-axis motor and perform automatic SR785 signal analyzer measurement by moving steps to the desired mm position. Location information can be saved as a file and reloaded and reused.
Battery Cell Charge/discharge test - Electrical &
Project Name: Battery Cell Charge/discharge test
Equipment used: Power Supply(IDRC DSP-006-100HR), Electronic Load(PRODIGIT MainFrame 3300G, Module 3316G), DAQ(Keysight 970A), DMM(Keysight DMM 34461A), RelaySwitch, ThermoCouple, LabVIEW
Contents: Test equipment capable of creating and executing any sequence for the Cell charge/discharge test. The sequence is mainly in the form of repeated charge-discharge, and can be completed or moved to a specific step when the condition specified in the step occurs.
BMA SV Line Performance Inspection - Car
Project Name: BMA SV Line Performance Inspection
End User: SLB (Ceroblithium Battery)
Equipment used: HIOKI BT3562, HIOKI ST5520, KEYSIGHT DAQ970a, CHROMA 19053, PSBE10060-510, CT-100G
Contents: This project is to inspect the performance of the BMA SV line production products of cubic lithium batteries. Product electrical characteristics and performance tests are conducted through various measuring instruments, the results are logged, and the inspection results are delivered by communicating with the control PC.
HILS SYSTEM CORRECTION - ELECTRIC & ELECTRONIC
Project Name:HILS SYSTEM CORRECTION
End User: Korean advance
Equipment used: PXIe-1095, PXIe-8881
Contents: This is the work of modifying the HILS system to verify the integrated control system for electric composite propulsion ships. As the system verification method was changed from H/W Wiring to verification through Modbus communication, the communication connection, variable setting, and operation sequence required for verification were modified.
Circular BPR Vision Inspection - Electrical &
Project Name:Circular BPR Vision Inspection
End User: DaemyungTS
Equipment used: USB-6001 DAQ, Basler-acA2500-14 gc Camera
Contents: This is a project that photographs the sealer application state of the sample with a camera and determines the condition. Check the sealer application state, and display the defective application state location on the screen to notify the user. It is also possible to manage the history of inspection results.
SCV200 - Electrical & Electronic
Project Name:SCV200_Sound&VibrationDataLogger
End User: HD Modern Site Solution
Equipment used: Mini Netbook, cDAQ-9171, NI-9231
Contents: This is a project to manufacture ultra-small measuring equipment that can easily measure and store noise & vibration data. It can collect up to 8 channels simultaneously and store up to 1 minute. A Weight Filter and BandPass Filter can be applied and FFT conversion is supported.
USRP SDR RF Receiver System - Electrical & Ele
Project Name:USRP SDR RF Receiver System
End User: National Radio Research Institute
Equipment used: LabVIEW & NI USRP-2940R, 120MHz BW, 50 MHz TO 2.2 GHz SDR
Contents: Processing unit to receive wirelessly radiated monitor signal (VESA standard). Receive and store all low data of the frequency set using NI USRP and LabVIEW.
Total Thermal Calibration - Defense & Electron
Project Name: Total Thermal Calibration
End User: SNT MOTIV
Equipment used: LabVIEW, PLC, Servo Press, Lenze
Contents: Measure the LVDT value before advancing to the press and the LVDT value of the total column after advancing to the press, drop the PIN, and if it is normal, correct it by the error value from the advanced PRESS and continue to advance the total column to correct the angle.
Contents: It is a project to inspect the performance of SNT Motive's TCCU line production products. Product performance inspection is performed through CAN communication, programmable power supply, and electronic load, and the results are logged and determined.
Piezoelectric power generation module program - El
Project Name : Piezoelectric power generation module program
End User: 이지에버텍
사용장비: LabVIEW, NI-6002, SHT30, ADXL337
내용: Set the desired setting value on the Settings tab and collect data using vibration, temperature, and humidity sensors.Temperature and humidity are measured every second. The vibration sensor begins to measure the moment the vehicle is detected.Calculate the power generation by taking the voltage and current values.In the case of vibration data, voltage, current, and power generation data are stored separately whenever the vehicle is detected, and temperature and humidity data are stored together.
Seal Rebound Force Measurement Tester - Electrical
Project Name: Seal Rebound Force Measurement Tester
End User: LG Electronics
사용장비: LabVIEW, LPS-30, DI-20W, SUA SPEED CONTROLLER
내용: Collect data using distance, force sensor, output the average value of seal repulsion over the set time when the set distance is reached in the table, and extract raw data in real time on the graph below
Noise Measurement System - Electrical & Electr
Project Name: Noise Measurement System
End User: Hyundai Construction Machinery
사용장비: cDAQ-9174, NI9234, LabVIEW
내용: A program that can measure noise dB and log data using a microphone. The 6-channel graph can be checked individually, the sensitivity of the microphone sensor can be automatically retrieved through the calibrator, and the noise average dB and the average dB of the entire logging data can be checked.
Water Level Sensor Frequency Measurement Device -
Project Name: Water Level Sensor Frequency Measurement Device
End User: LG Electronics
사용장비: LabVIEW, cDAQ-9178, NI 9411, NI 9478, NI 9435
내용: It is an equipment that analyzes frequency data of a washing machine water level sensor according to a change in water level and determines the sum of the products. The water level is precisely controlled through servomotor control. Regular Top Loader
Particle Checker - Electrical & Electronics
Project Name: Particle Checker
End User: Dongjin Semichem
사용장비: LabVIEW, Vision Development Module
내용: Save the photos taken under a microscope by folder and search for particles (foreign materials) through image processing. Particles are classified by size and determined positively/disregardably based on the user-specified reference value.
IR Temperature Sensor Measuring - Electrical &
Project Name: IR Temperature Sensor Measuring System
End User: Shinsung Delta Tech
사용장비: LabVIEW, UART Serial
내용: It is a program that communicates with equipment that tests IR temperature sensor module to show the results of the payment on the screen and stores the results of the measurement. Store the daily production volume and the results of the judgment, and sound the alarm when the IR temperature sensor module is defective.
Multi-channel Data Collector - Electrical & El
Project Name: Multi-channel Data Collector
End User: Busan National University
사용장비: LabVIEW, Scanivalve ZOC22B, SCXI AI, SCXI DO
내용: Scanvalve's ZOC22B multi-channel pressure sensor uses SCXI equipment to select channels and collect data. It is possible to select channels using 5bit DO, and to display and log representative values for one channel data logging, multi-channel slow switching logging, and multi-channel fast switching channels.
Dynamo Motor Test - Electrical & Electronics
Project Name: Dynamo Motor Test
End User: Aerospace Research Institute
사용장비: LabVIEW, NI-9188
내용: Graph data generated during motor test (voltage, current, temperature, RPM, etc.) and data sent and received by RS485 communication